Agri Vehicles Insurance from Greenlands

Author Topic: Preserving apple sauce  (Read 2591 times)

nannyplum

  • Joined Jul 2016
Preserving apple sauce
« on: October 28, 2016, 11:36:34 am »
I know that the large amount of sugar is the main preserver in jam, but would apple sauce in jars also work? I intend to make apple sauce and  then put it whilst hot into small hot jars and lid immediately. Would  I get at least 6 months shelf life?  No room left in the freezer, this is the only option. Views please.
thanks

devonlady

  • Joined Aug 2014
Re: Preserving apple sauce
« Reply #1 on: October 28, 2016, 12:36:52 pm »
I will look through my old preserving books. Meanwhile could you dry apple slices? Or, apples keep well, wrapped in newspaper and stored in a cool dry place.

cloddopper

  • Joined Jun 2013
  • South Wales .Carmarthenshire. SA18
Re: Preserving apple sauce
« Reply #2 on: October 28, 2016, 08:38:21 pm »
Yes apple sauce will store well in a vacuum sealed jar that has a rubber air seal to keep the vacuum in place , such as a screw top Kilner/ Mason  preserving  jar or a Weck preserving jar , it tends to go a darker colour in the jar even in the fridge after nine months .

 It may be I needed to add lemon juice to & even more sugar to keep the lighter colour , the apples I used were 3 kg of Bramley's  & made up as an apple  sauce for pork they were pressure canned in my Weck preserving jars  .

 You say no room in the freezer . not even for small twists of cling film in three or four thicknesses  filled with three dessert spoons of apple sauce and stuffed into every nook & cranny that exists in the freezer ?
 
 I'll have a peek at " hot water bath preserving " for your screw top jar idea, if it is a goer  make sure you use new lids with the heat setting seals in them  .

 Yep , hot water bath preserving is OK ....according to the Dummies guide to Canning & preserving , but is is for preserving apple slices in Syrup not as an apple sauce , so I suspect it is not viable or perhaps it's even dangerous wrt toxins developing  to do as apple sauce in a hot water bath canner .


  Anyway just in case you want to try the " Hot water bath preserving method " I've typed up what we do & have given you some figure to think of & work with  .

Here is a quick rundown of the method for apple slices  in Syrup , I'm sure you could convert a preserved jar of slices in heavy syrup to apple sauce for a week or so of  fridge use as & when needed .
 I've perhaps gone over board in typing it up for someone who knows exactly what they are doing but fel it may also help bring someone on the fringes of pressure canning & hot water bath preserving a little further into the fold  .

 .

Sugar  1/4 cup ( super light syrup ) to 4 & 1/2 cups ( heavy syrup )

Don't use wind fall fruit , it's liable to be too ripe and not high enough quality for long term storage .

Peel & core the apples , slice & to stop discolouration treat with an antioxidant ....they are all forms of vitamin C .....such as ascorbic acid tablets  or citric acid or see if you can get powdered vitamin C for preserving at a health food shop . You'll need to look up how much to use per quart /litre of syrup etc .

 Remove any air bubbles in the jars with a non metallic stirrer . 
Leave 1/2 " ( 13 mm ) head space of air in the jars , this allows a decent vacuum to form and seal the jar as it cools  Too much or too little air space sees the lid sealing  fail quite often and you don't want the resultant botulism poisoning do you ?


So  make your syrup to your own preference .

Sort your apples & make the slices 1/4 " (  6 .5 mm ) thick .

Pack the apples firmly into hot jars & pour on the boiling syrup once the jar is full ...leaving that vital 1/2 inch head space of air .

ONLY LIGHTLY TWIST THE JAR LIDS ON to get a light seal ...TOO TIGHT AND THE AIR WHEN HEATED WILL NOT BE ABLE TO ESCAPE PAST THE RED OR WHITE RUBBER SEALANT ( THE SEALANT ON ALREADY USED LIDS IS NOT MUCH GOOD TO GET A DECENT SEAL.  NOT TIGHT ENOUGH AIR CAN RE-ENTER AS THE JARS COOL & CAUSE FOOD POISONING .
 The idea is to get the seal to act like a one way valve .
 
Mum used to take the jars out of the boiling water in the hot water canning bath  using the old wooden long pronged washing tongues and stand the very hot jars on the  wooden table then hold each jar in a tea towel and use an oven glove  to nip the lid tight  . 
 Don't put them on a cold surface use some flat wood or a plastic chopping board as the sudden cold will also shatter the jars sendnig scalding sugar & fruit all  over you & the dog etc .

 You'll need a trivet or wire rack in the bottom of a large deep pan to make a stand off from the bottom of the pan to stop the jars conducting too much heat from the heat source through the aluminium pans metal.  you're after the temperature of the boiling water only no more & no less .. this stops the jars shattering or cracking  .

 No jars are allowed to touch each other , nor touch the sides of the pan .  Again this is to do with the heat transfer and too much expansion that results in a bust jar . 

Only use jars of the same volume & height  ( vitally important ) so they all get cooked & sealed to the same levels .

Put the hot filled & now lidded  jars in an open hot water bath of boiling water with an inch or slightly more of boiling water above the tops & time the sterilization for  20 minutes  exactly , have a kettle of boiling water handy to adjust the height of the water to that vital one inch above the tops of the lids on the jars  .

 When the timed period is up....
Take care lifting the jars out the hot water bath  , I often leave them in & allow the water to cool enough for me to pick the jars out by hand .

Whilst the jars are still fairly hand hot give the lid a micro tweek to tighten it fully then stand the jars on a tripple folded towel and let them cool naturally ...don't be tempted to use cold water to cool them down as again you'll cause the jars to crack for the contents at the center of the jar it can still be nearly at boiling point .
 

Finally when the jars are cool enough to handle them with your bare hands , make the labels up and put them on the now hand hot warm jars . Store you jars in a cool dark place  .
« Last Edit: October 30, 2016, 01:24:05 pm by cloddopper »
Strong belief , triggers the mind to find the way ... Dyslexia just makes it that bit more amusing & interesting

cloddopper

  • Joined Jun 2013
  • South Wales .Carmarthenshire. SA18
Re: Preserving apple sauce
« Reply #3 on: October 28, 2016, 09:55:53 pm »
 What I've been using is this book ( plus other specialist ones )

CANNING & PRESERVING  , All in one For DUMMIES ,  6 books in 1

ISBN CODE 978-10118-03419-4

  I got mine from Amazon , two maybe three years ago,  for a lot less than the £ 17.99 it was offered at .
Strong belief , triggers the mind to find the way ... Dyslexia just makes it that bit more amusing & interesting

Ghdp

  • Joined Aug 2014
  • Conwy
Re: Preserving apple sauce
« Reply #4 on: November 07, 2016, 09:19:35 pm »
Just been given this recipe tonight for cider apple butter. Hugh F-W recipe I think. Obviously not done it yet but comes highly recommended to me.

1.5 kg of cooking apples
600 ml dry or medium cider
granulated sugar
Half tea spoon cloves
Half tea spoon ciinnamon

No need to peel or core apples( if using windfalls cut away bruised damaged bits.) Chop apples into fairly big bits( about 8)  place in a large plan with cider and 600 ml of water. Cook gently til soft, them remove from heat.

Push apple mixture through a nylon sieve or use a mouli to reduce it to a puree. Weigh the fruit pulp and return it to the cleaned out pan adding 340g of sugar to every 600 ml of fruit pulp. Add cloves and cinnamon. Slowly brin to the boil stiring until sugar has disolved, then boil rapidly for 10 -15 mins until mixture begins to splutter and is thick and creamy.

Remove from heat and pour immediately into warm, sterilised jars. Small jars recommended as this low sugar preserve has realtively short shelf life once opened. Seal immediately. Use within 12 months

Ghdp

  • Joined Aug 2014
  • Conwy
Re: Preserving apple sauce
« Reply #5 on: November 07, 2016, 09:22:02 pm »
Not sure why the sunglass wearing smiley face appeared in this. It should have said cut into fairly large pieces ( about 8)

Ghdp

  • Joined Aug 2014
  • Conwy
Re: Preserving apple sauce
« Reply #6 on: November 07, 2016, 09:22:47 pm »
Ok , I give up. Fairly large pieces ( about eight)

doganjo

  • Joined Aug 2012
  • Clackmannanshire
  • Qui? Moi?
    • ABERDON GUNDOGS for work and show
    • Facebook
Re: Preserving apple sauce
« Reply #7 on: November 11, 2016, 05:49:58 pm »
LMAO  :roflanim:
Always have been, always will be, a WYSIWYG - black is black, white is white - no grey in my life! But I'm mellowing in my old age

 

Forum sponsors

FibreHut Energy Helpline Thomson & Morgan Time for Paws Scottish Smallholder & Grower Festival Ark Farm Livestock Movement Service

© The Accidental Smallholder Ltd 2003-2024. All rights reserved.

Design by Furness Internet

Site developed by Champion IS